Karnataka is a pioneer state for on-grid rooftop solar. With innovative policies, it was responsible for a huge surge in interest from all sections of society to install rooftop solar plants.

For technical and economic reasons, rooftop solar policy makers prefer to target “prosumers” i.e., consumers of electricity who wish to also produce electricity in amounts comparable to their consumption. Due to the erstwhile lucrative policy wording, a large number of applicants for large rooftop solar plants were found to be minor consumers of electricity. For instance, agriculturalists lined up to set up large “rooftop” plants on open land by constructing a shed. This went against the spirit of the rooftop policy, and rooftop solar electricity producers started looking very much like ground-mounted solar producers (which come under a different policy and have lower buyback rates for sound reasons) A mid-course policy correction was thus inevitable and KERC announced the new rooftop solar tariff and rules in May 2016.

Salient changes in Karnataka rooftop solar policy 2016

  1. Maximum size of solar plant limited to 150% of sanctioned load / contract demand: This is still liberal compared to other states that limit the plant size to the sanctioned load or less.
  2. For residential, educational institutions and hospitals, net metering is no longer applicable. These prosumers will be instead compensated via gross metering: The justification for this shift was that many consumers felt shortchanged by net metering (since consumer electricity tariffs are lower than the solar purchase tariffs) and wished a uniform buyback rate for all the electricity they produced.
  3. Capacity based buyback tariffs: Whereas earlier all consumers got ₹9.56 for every excess unit of electricity generated, new plants will be compensated as per the following tariffs:
Capacity of Solar Rooftop and small PV power plants Approved Tariff in ₹/Unit (Without Capital Subsidy) Approved Tariff in ₹/Unit (With Capital Subsidy of 15%)
1 to 10kW 7.08 6.03
Above 10kW and upto 50kW 6.61 5.63
Above 50kW and upto 100kW. 6.14 5.23
Above 100kW and upto 500kW 5.67 4.83
Above 500kW and upto 1MW 5.20 4.43

These rates are fixed for the duration of the 25 year Power Purchase Agreement (PPA).

This tariff schedule effectively removes any advantage larger system owners had due to economics of scale, and also ensures the overall financial benefit per unit for subsidized and unsubsidized systems is the same. Also, no subsidy has been disbursed by the state nodal agency KREDL as per our knowledge. We therefore recommend not to pursue the subsidy option.

Sizing considerations

From the above policy, Oorjan recommends the following sizing for your rooftop solar project if you are a residential, educational institution or hospital consumer. You should go with the maximum sized rooftop solar system possible, subject to:

  1. 150% of your sanctioned load (Your sanctioned load is mentioned in kW on your electricity bill)
  2. Available roof area: 1 kW requires approximately 100 sq ft of shade free rooftop space.
  3. If the kW value calculated from 1 and 2 above is close to a capacity tariff tier, round it down to the maximum capacity.

Sample calculation: If your sanctioned load is 10kW, you should consider a system size of 10 * 150% = 15kW. This requires 1500 sq ft roof space. However, if you have only 1100 sq ft space available, the size gets limited to 11kW. Since the tariff changes at 10kW, a 10kW system would be best for you.

Returns Calculation

How much would investing in a 10kW rooftop solar system return on purely financial terms? A 10kW system will generate on average 1250 units of electricity every month. The earnings from selling this energy to the discom (BESCOM / MESCOM / HESCOM / GESCOM / CESCOM) are ₹8,850 per month. Assuming a turnkey project cost of ₹7.72 lakh, this would imply a simple annual return on investment (ROI) of 13.8%, which is quite attractive.

To be conservative, we further assume the following:

  • Panel output degradation of 1% per year
  • Maintenance / wear and tear budget of ₹750 per month with inflation at 3% per year
  • Zero salvage value at the end of the PPA

The internal rate of return (IRR) of the rooftop solar system now reduces to 10.8% per year. This is still a higher ROI than keeping your money in the bank or many other long term investment avenues! In addition, there are the non-financial benefits of going solar, such as contributing towards a greener and cleaner planet.

You can use our online returns calculator to modify and get a feel for these numbers.

Contact us today to get started on rooftop solar in Karnataka!


Go green and save!
Click on the button below to get started.


Signup and get notified when we publish new articles.

Similar Posts

solar powered garden lights
May 18, 2018
Solar power plant
May 18, 2018

8 Replies to “Rooftop solar in karnataka – sizing and financial returns”

    1. Hi Sharath. Over the past year, Karnataka has modified the rules for rooftop solar. Earlier one could set up rooftop solar of any size on open land. Now that is no longer possible. Firstly, the size of the rooftop solar is limited to your sanctioned load in kW. So to set up a 50kW plant, you will need to have an existing electricity connection of 50kW. Secondly, the Power Purchase Agreement (PPA) will only be signed if there is an existing roof that will support the panels. For 50kW, you will need roof area of 4000-4500 sq ft. If you have both of these, do submit your contact details on our online estimator and someone from our team will reach out to you.

  1. Hi,
    I m planning for rooftop but little hesitant with grid as I wish to take it off grid. My sanctioned limit is 3, and hav a roof at 4-5kv.
    Can you give me the difference between off grid vs grid pls?

    1. Sir: I live in my 2 bedroom apartment in a condominium in Mysore. I wish to go in for a solar power plant for my apartment . My sanctioned load is 0.00HP +3.00 kw. There is sufficient space in my rooftop to install the solar
      system. My average monthly electricity consumption is 300 units p.,m. (without Air condition). I wish to install a on-grid solar power system. Kindly guide me what it will cost me and if I can sell the excess power to the Chamundi Elec.Supply Distribution Co.,Mysore? I require subsidy by Government.. Kindly replyh me

  2. I have a vacant plot near bangalore. I am thinking of leasing the space to a solar company like yours, where you can install the power plant and supply to grid, and pay the rent to me
    Do you take up such works? Please do let me know. The space is sufficient to install 10kw capacity

  3. Rooftop solar system is really awesome ideas to save electricity and keep our environment clean by minimizing the carbon footprints and there are customized Rooftop solar panels available according to the rooftop. Thanks for sharing such valuable info.

Leave a Reply

Your email address will not be published. Required fields are marked *


Go Green and Save!

Please fill the form below for Oorjan product updates via Email/SMS